Airflow performance injection12/20/2023 ![]() Steffens J, Coury JR (2007a) Collection efficiency of fiber filters operating on the removal of nano-sized aerosol particles: I-homogeneous fibers. ![]() ![]() ![]() Song M, Im SJ, Liu DHF et al (1997) Environmental engineers’ handbook: air pollution, 1st edn. Simon X, Bémer D, Chazelet S et al (2014) Downstream particle puffs emitted during pulse-jet cleaning of a baghouse wood dust collector: influence of operating conditions and filter surface treatment. Saleh AM, Tafreshi HV (2014) A simple semi-numerical model for designing pleated air filters under dust loading. Rothwell E (1988) Design and operating characteristics of reverse\\jet assemblies for pulse-jet dust collectors. Qian YL, Bi YX, Zhang Q et al (2014) The optimized relationship between jet distance and nozzle diameter of a pulse-jet cartridge filter. Qian YL, Chen HY, Dai HD et al (2018) Experimental Study of the Nozzle Settings on Blow Tube in a Pulse-Jet Cartridge Filter. Mao N, Yao YP, Kanaoka C (2006) Comparison of filtration performances of cleanable fabric filters measured by VDI and JIS testing rigs. Lu HC, Tsai CJ (1996) Numerical and experimental study of cleaning process of a pulse-jet fabric filtration system. Lo LM, Hu SC, Chen DR et al (2010b) Numerical study of pleated fabric cartridges during pulse-jet cleaning. Lo LM, Chen DR, Pui D (2010) Experimental study of pleated fabric cartridges in a pulse jet cleaned dust collector, Powder Technology. Liu TN, Lin LY, Yan CP et al (2018) Pulse jet blowing air flow deflection of soot cleaning process. Lin LY, Chen HY, Jiang YY et al (2010) Influence of supersonic nozzle on dust-cleaning efficiency of pulse-jet cartridge filters, Journal of HV&AC. Li SH, Zhou FB, Xie B et al (2018) Influence of jet pipe characteristics on pulse-jet cleaning uniformity in a pleated cartridge filter. Li QQ, Zhang MX, Qian YL et al (2015) The relationship between peak pressure and residual dust of a pulse-jet cartridge filter. Li HX (2016) Numerical analysis on the gas flow dynamics from a rectangular slot-nozzle for pulse cleaning of filter unit. Koch M, Krammer G (2016) Filter performance with non-uniformly distributed concentration of dust-evidence from experiments and models. Ju M, Zhang MX, Chen JD et al (2013) Dynamic analysis of dust dislodgement from pulse-jet cartridge filter, Chinese. Humphries W, Madden J (1983) Fabric filtration for coal-fired boilers: dust dislodgement in pulse jet filters. Hu JL (2017) Numerical simulation research on pulse cleaning system of cartridge dust collector.Xi'an University of Architecture and Technology J Membr Sci 216(1):121–134ĭ’souza NM, Mawson AJ (2005) Membrane cleaning in the dairy industry: a review. Powder Technol 291:284–298Īrgüello MA, Alvarez S, Riera FA et al (2003) Enzymatic cleaning of inorganic ultrafiltration membranes used for whey protein fractionation. Therefore, it is proved that the diversion nozzle can effectively correct the jet airflow deflection.Īndersen BO, Nielsen NF, Walther JH (2015) Numerical and experimental study of pulse-jet cleaning in fabric filters. After installing the diversion nozzle, the results show that the peak static pressures of the face-flow and back-flow surfaces are basically the same. The experimental results show that the sidewall peak static pressure of the face-flow surface of the filter cartridge is greater than that of the back-flow surface due to deflection, and the difference between the two is proportional to the jet-hole diameter and jet pressure. Under more comprehensive conditions, such as jet pressures, jet distance, and jet-hole diameter, the influence of the pulsed jet airflow deflection on the cleaning performance of the filter cartridge has been discussed systematically, by testing the peak static pressure on the side wall of the filter cartridge. But perhaps due to the lack of effective testing methods, the impact of pulsed jet deflection on dust cleaning is often ignored. The phenomenon of pulsed jet airflow deflection exists during pulse jet cleaning, which causes a large impact on the local area of filter cartridge and shortens the service life of the filter cartridge. However, pulse-jet cleaning is not uniform on the filter cartridges. Pleated cartridge filters are widely used to remove dust in industrial processes. ![]()
0 Comments
Leave a Reply.AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |